As a not-for-profit utility, Dawson PPD focuses on cost-effectively extending the life of its existing facilities while maintaining adequate levels of safety and reliability. Testing wooden poles helps the District ensure reliability and long life of its equipment, saving customers money in the long run.
Traditionally, pole testing involved a hammer for sounding, a shovel for digging around the base and drilling holes to test for decay. Today, Dawson PPD hires a contractor that uses a scientifically-based system called POLUX as a less-invasive and more accurate form of testing.
POLUX works by sending two, three inch long probes the size of an eight-penny nail into the base of the utility pole. This is the most vulnerable point where decay is most likely to occur on a pole. The probes measure resistance and moisture content of the pole. This information, along with the type of wood the pole is made of and how it was treated are run through a computer program with the pole’s GPS location recorded.
Typically, Dawson PPD uses a Southern Yellow Pine tree for its poles, which should have a resistance of 8,000 pounds per square inch when new. If the measurement falls below 50 percent of the recommended resistance, in this case 4,000 PSI, the pole is marked for replacement.
All of Dawson PPD’s poles are tested every 10 years on a rotating schedule with 10,000-11,000 poles tested annually.
OTHER NEWS
From Apprentice to Journeyman
Dawson PPD lineworkers obtain journeyman status through formal training program Just because they have a utility line degree, doesn’t mean that lineworkers may officially hang up their mortar board. They’ll have to go through another four years of on-the-job training,...
Let’s talk public power
October is Public Power Month. Read how Dawson PPD works to serve you. Did you know that Nebraska is the only state in the nation served entirely by public power electric utilities? Community-owned utilities mean that Nebraskans are working for Nebraskans. Public...
Between the lines: Why solar just can’t plop anywhere
By Gwen Kautz, Dawson PPD General Manager gkautz (at) dawsonpower.com 308-324-2386 You’re looking over a piece of land you’ve owned for years that, quite frankly, has seen better days. It’s not prime land and it’s difficult to farm. You look down at a flyer in your...