As a not-for-profit utility, Dawson PPD focuses on cost-effectively extending the life of its existing facilities while maintaining adequate levels of safety and reliability. Testing wooden poles helps the District ensure reliability and long life of its equipment, saving customers money in the long run.
Traditionally, pole testing involved a hammer for sounding, a shovel for digging around the base and drilling holes to test for decay. Today, Dawson PPD hires a contractor that uses a scientifically-based system called POLUX as a less-invasive and more accurate form of testing.
POLUX works by sending two, three inch long probes the size of an eight-penny nail into the base of the utility pole. This is the most vulnerable point where decay is most likely to occur on a pole. The probes measure resistance and moisture content of the pole. This information, along with the type of wood the pole is made of and how it was treated are run through a computer program with the pole’s GPS location recorded.
Typically, Dawson PPD uses a Southern Yellow Pine tree for its poles, which should have a resistance of 8,000 pounds per square inch when new. If the measurement falls below 50 percent of the recommended resistance, in this case 4,000 PSI, the pole is marked for replacement.
All of Dawson PPD’s poles are tested every 10 years on a rotating schedule with 10,000-11,000 poles tested annually.
OTHER NEWS
Fresh off the farm
Raw milk is a trend that consumers are starting to latch on to, but it can be difficult to find a supplier. Fortunately for central Nebraska, The Milk House serves high quality, nutritious raw milk with the help of its six Jersey and Jersey-cross cows. Rancher...
The pros and cons of overhead and underground power lines
Overhead Pros: Less expensive to build and repair Easier to spot faults/damage Can be built on any terrain Cons: Susceptible to wind, ice and snow More vulnerable to damage from trees and vegetation More vulnerable to blinks caused by animals Susceptible to damage...
Between the lines: Merger update
It’s time to update you on the possible merger between Dawson Public Power District and The Central Nebraska Public Power and Irrigation District. February was a busy month and an important milestone in the process. The districts held a joint board meeting in Kearney...